Davey X90 Water Pressure Systems User Manual download pdf

Installation and

Operating Instructions

for Dynajet

X50 / X70 / X90

Water Pressure Systems

Trouble Shooting Check List

a) MOTOR RUNS WHEN SWITCHED ON BUT DOES NOT PUMP.

 1. Suctionlineandpumpbodynotlledwithwater.

 2. Airleaksinsuctionlinesorsuctionpipenotunderwater.

 3. Airtrappedinsuctionlines(alsopossiblewithoodedsuctiondueto

unevenriseinpiping;eliminatehumpsandhollows).

 4. Nowateratsourceorwaterleveltoolow.

 5. Valveonsuctionlinesclosed.

b) PUMP SWITCHES ON AND OFF FREQUENTLY (CYCLING)

 1. Checkthattankairpressureiscorrect-seeabove.

 2. Leakingtaps,oatvalvesetc.checkplumbing.

 3. Leakingcheckvalve/footvalve.

c) MOTOR DOESN’T START WHEN SWITCHED ON.

 1. Powernotconnected.

 2. Supplyvoltagetoolow.

 3. “Overtemperature”cut-outtripped.*

 4. Motornotfreetoturneg.ajammedimpeller.

 5. Internalmotorfault.

Checking and Replenishing Tank Air Charge

Supercell“P”PressureTanksdonotrequireregularchecks

undernormaloperatingconditions,Ifairchargeadjustment

isrequiredthenfollowthefollowingprocedures:

1. Releaseallwaterpressurefromthepressuretankby

switchingoffthepumpatthepowerpoint,andopeningthe

closettap.Forabovegroundsupplytanksitisnecessary

toclosethegatevalvebetweenthesupplytankandthe

pump.

Leavetapopenduringairreplenishment.

2. Whenallwaterpressurehasbeenreleasedfromthesystem,checkair

pressureatairvalveontopofpressuretank.Thestandardpre-charge

pressurereadingshouldbe165kPaforX50and190kPaforX70andX90

models.Inanycasethepre-chargeshouldbesetat15kPabelowcut-in

pressure.

3. Ifnecessary,replenishairchargetothecorrectpressureindicated.Ensure

thatatapinoutletpipingofpumpsisopenduringreplenishmentofair

precharge.

Period Checks

Flushing:Dependingonthequalityofthepumpedwater,fromtimetotime,

yourtankmayrequiredushingtoremovesettlednessuchasmudorsand.

Ifsandormudisallowedtostayinthetank,itwillacceleratewearonthe

internalliningandshortenyourtank’slife.

Safelydisconnectthetankfromthewatersupply,dischargeallairfromthe

tankandushthetankseveraltimeswithcleanwater.Oncetheushing

waterisclean,reconnectthetankandrechargetheairasperabove.

Externalinspection:Atankingoodorderwillnotleak,butovertimedueto

damagethroughroughhandling,impactsorgritand/orimpuritiesinthewater,

thetankshellmayfailand/orleak.Shouldthetankleakorshowsignsof

possiblefailure,thetankshouldbeimmediatelydisconnectedandreplaced.

Please pass these instructions on to the operator of this equipment.

*NOTE: For protection, the Davey pump motor is tted with an

automatic “over temperature” cut-out. Constant tripping of this

overload device indicates a problem eg. low voltage at pump,

excessive temperature (above 45

C) in pump enclosure.

Care should also be taken when servicing or disassembling pump to

avoid possible injury from hot pressurised water. Unplug pump, relieve

pressure by opening a tap on the discharge side of the pump and allow

any hot water in the pump to cool before attempting to dismantle.

WARNING: When servicing or attending pump, always ensure power

is switched off and lead unplugged. Electrical connections should be

serviced only by qualied persons.

During servicing, use only approved, non-petrochemical based oring

and gasket lubrication. If unsure, consult your Davey Dealer for advice.

WARNING: Do not use hydrocarbon based or hydrocarbon propelled

sprays around the electrical components of this pump.

In accordance with AS/NZS 60335.2.41 we are obliged to inform you that this

pump is not to be used by children or inrm persons and must not be used as a

toy by children.

WARNING: Failure to follow these instructions and

comply with all applicable codes may cause serious

bodily injury and/or property damage.

NOTE: Prior to installation remove the red transport

plugs & associated seals from the suction and/or

discharge ports.

CAUTION: To prevent personal injury, ensure all water pressure is released

from the pressure system prior to work being performed.

NOTE: During air replenishment the tank should be externally inspected. Any

signs of leakage from the tank may indicate a need for immediate replacement.

WARNING: Do not use tank if it leaks or shows signs of corrosion or damage.

Davey

Repair or Replacement Guarantee

In the unlikely event in Australia or New Zealand that this Davey product develops any malfunction within two years of the date of original purchase due to

faulty materials or manufacture, Davey will at our option repair or replace it for you free of charge, subject to the conditions below.

Should you experience any difculties with your Davey product, we suggest in the rst instance that you contact the Davey Dealer from which you

purchased the Davey product. Alternatively you can phone our Customer Service line on 1300 367 866 in Australia, or 0800 654 333 in New Zealand, or

send a written letter to Davey at the address listed below. On receipt of your claim, Davey will seek to resolve your difculties or, if the product is faulty or

defective, advise you on how to have your Davey product repaired, obtain a replacement or a refund.

Your Davey Two Year Guarantee naturally does not cover normal wear or tear, replacement of product consumables (i.e. mechanical seals, bearings or

capacitors), loss or damage resulting from misuse or negligent handling, improper use for which the product was not designed or advertised, failure to

properly follow the provided installation and operating instructions, failure to carry out maintenance, corrosive or abrasive water or other liquid, lightning

or high voltage spikes, or unauthorized persons attempting repairs. Where applicable, your Davey product must only be connected to the voltage shown

on the nameplate.

Your Davey Two Year Guarantee does not cover freight or any other costs incurred in making a claim. Please retain your receipt as proof of purchase; you

MUST provide evidence of the date of original purchase when claiming under the Davey Two Year Guarantee.

Davey shall not be liable for any loss of prots or any consequential, indirect or special loss, damage or injury of any kind whatsoever arising directly

or indirectly from Davey products. This limitation does not apply to any liability of Davey for failure to comply with a consumer guarantee applicable to

your Davey product under the Australian or New Zealand legislation and does not affect any rights or remedies that may be available to you under the

Australian or New Zealand Consumer Legislation.

In Australia, you are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You

are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.

Should your Davey product require repair or service after the guarantee period; contact your nearest Davey Dealer or phone the Davey Customer Service

Centre on the number listed below.

For a complete list of Davey Dealers visit our website (davey.com.au) or call:

* Installation and operating instructions are included with the product when purchased new.

They may also be found on our website.

P/N 48660-9 supersedes P/N 48660-8

AUSTRALIA

Customer Service Centre

6 Lakeview Drive,

Scoresby, Australia 3179

Ph: 1300 367 866

Fax: 1300 369 119

Website: davey.com.au

Davey Water Products Pty Ltd

Member of the GUD Group

ABN 18 066 327 517

NEW ZEALAND

Customer Service Centre

7 Rockridge Avenue,

Penrose, Auckland 1061

Ph: 0800 654 333

Fax: 09 527 7654

Website: daveynz.co.nz

® Davey & Dynajet are registered trade marks of Davey Water Products Pty Ltd.

1 2

Summary of Contents

Page 1 - Water Pressure Systems

Installation andOperating Instructionsfor Dynajet®X50 / X70 / X90Water Pressure SystemsTrouble Shooting Check Lista) MOTOR RUNS WHEN SWITCHED ON BUT

Page 2

Choosing a SiteChooseasitewitharmbaseandasclosetothewatersourceaspossiblewithcorrectpowersupply.Makesureyourpressuresystemis

Comments to this Manuals

No comments

Davey X90 Water Pressure Systems User Manual

Browse online or download User Manual for Pumps Davey X90 Water Pressure Systems. Davey X90 Water Pressure Systems User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Pumps Davey X90 Water Pressure Systems